Hand Tool Headlines
The Woodworking Blogs Aggregator
“Glory to God in the highest heaven, and on earth peace to those on whom his favor rests.” - Luke 2:14
Be sure to visit the Hand Tool Headlines section - scores of my favorite woodworking blogs in one place.
Norse Woodsmith Blog Feeds
last new project to end 2025......pt VIII
Today I had my post hospitalization check up. I still have the cough and the snot locker filling constantly but I do feel a lot better. The bitter, biting cough I had before is gone. The one now I feel in my chest with hacking up phlegm by the bucket. The cough is gentler and I don't feel like putting a gun to my head when I do cough.
The doc gave me a Rx for a cough suppressant and something to help with the phlegm. On the 29th I have a pulmonary function test and on Jan 9th I have another MRI. That is the one I'm anxious about because it will reveal whether I had pneumonia or lung cancer. The important thing in my mind is that I had an improvement in my condition be taking the pneumonia antibiotics. Fingers crossed till the tell tale MRI.
| happy face on |
The base stock behaved over night. I was expecting to see the long ones to be curled up like pretzels. The right long has a bit of bow to it but I can easily work around that.
| new template |
Not much difference in them. The bottom one is only an inch taller than the top one.
| one down and one to go |
I put the tails on the short ends so the from the front the view will be square - ish tails vice triangular pins. This is where I killed the lights to go to the VA. New traffic patterns/construction on RTE10 made that a fun ride. Glad that I left early.
| filler on the latch side |
This had been cooking in the clamps for two days. Unclamped it and sawed the ends flush. I will leave the shim full width until I get the hinges installed.
| hmmm....... |
Both doors would not lay in the opening square. Penciled the shim overlay and it was tapered. Realized that I had fitted the doors to fit with the carcass in a specific orientation this way wasn't it. Flipped it 180 and both doors laid up square in the opening. The gap on the latch side was now parallel top to bottom. Labeled the top/bottom along with the L and R.
| last three |
No surprises chopping the pin waste. Another thing I was bit apprehensive about due to the case hardening I saw when ripping the stock.
| fits |
This baser is snugger than the first one I did. It was a frog hair or two too snug but I managed to get it on. The length has about a 1/8" of wiggle room while the width has none.
| base cutout done |
I double, triple checked this before I bandsawed out the waste. I have done this in the past with one leg cut out in the wrong direction. Tends to suck the wind out of the sails in a heart beat.
| tricky cut out |
I couldn't bandsaw the waste in one continuous cut. However, I could gang them together and rasp the cutouts even and smooth.
| different op for the long ones |
I ganged the two long ones together and rasped the ends together. The long straight run between the ends I did individually.
| one more dry fit |
I sanded the insides of the base with 80 grit and that helped a wee bit. It was still snug but was easier to get it started. Glued it and put it back on to cook in place. The clamps are there to keep it from sliding down.
Tomorrow I'll get the bearers installed and eyeball how the bookcase looks with the base attached. I should be able to finish this before the new year shakes hands with me.
accidental woodworker
last new project to end 2025......pt VII
| came too late |
Whenever I see these I usually buy them, especially the war time publications. This one is packed with wood characteristics, plans, and repair procedures. I wish I had gotten it before I started the last project for this year.
| look familiar |
What struck me was the door stop detail at the top and the bottom. The top stop is something I haven't seen before and it would have worked perfectly for my two door bookcase.
| after dinner |
I went back to the shop, chopped the pins, dry fitted the base, and checked the fit on the carcass. It was a little snug on one corner but I moved the opposite corner until it slipped over the carcass. I didn't bother squaring the base - I used the carcass to set the fit.
| template |
None of the templates I already had looked good to my eye. Once I'm done using it I'll put with the other templates.
| done |
Got all four cutouts done with one continuous saw cut on the bandsaw. After cleaning the saw cuts with planes, spokeshaves, and 100 grit sandpaper, I was ready to glue it up.
| big sigh |
Got the base glued up and all the tails fully seated. The plan was to use the carcass to hold the base as it cooked. However, it dawned me here that I had done a huge brain fart that still the smell still lingers in the shop. I made this base way too big. If fits in this orientation but it is the wrong one.
This is without a doubt one of, if not the #1 bone head me-steaks I have made in the shop ever. I don't know how I hadn't seen this the previous night. I only saw it after the base was glued and on the carcass and I was thinking of the doors. That is when the bells started to ring and echo in the brain bucket.
I don't think this me-steak is something I will be able to recycle into using on something else. But just in case I will stow it in the boneyard after it has cooked.
| new base |
After the base screw up I left the shop. I got all my xmas shopping done and everything wrapped and ready to go. Stickered the new base stock but I don't have a good feeling about it. The pine seemed to be case hardened a wee bit. I had a devil of time ripping the long pieces. The blade pinched on the kerf for the first 1/3 of the rip cut. Got it done and I'll find out in the AM if this had stupid wood tricks up its sleeves.
| one of the first base cut offs |
Cleaned up and ready to layout for the shelf pins.
| layout done |
Didn't plan it this way but it worked out in my favor. The last position on the drill guide is 7" from the bottom and the top one is 7 1/8" from the top.
| almost 6" |
One good thing about the screw up is the base is now almost at the 6" I originally wanted. I will have to make a new template as the original is 4 1/2".
Found some brass hinges from Horton Brasses that I like -$83 shipped. I'll dig into my wood stash $$$ and buy them probably next week. But now I have the problem of knobs for the doors. The added headache is I will have to work around the door astragal. There isn't a lot of real estate to play with between the astragal and the knob size.
accidental woodworker
Chisels for Kumiko
While paring kumiko In the past I’ve often thought that I could create a tool to make this task a bit easier and possibly more ergonomic as well. Recently I had a customer/friend contact me to inquire as to whether I would be interested in creating such a chisel for him.
I made a list of the criteria we put together for this chisel:
(1) Wide blade for easy registration on the jigs typically used in kumiko work.
(2) Shorter blade so the pressure point of your hand is close to the cutting contact point. Something butt chisel length.
(3) Shorter handle as compared to a bench chisel so the end would fit comfortably in your hand and provide a way to push with the butt of your hand.
(4) A lower bevel angle to make for a better paring cut.
(5) Lower heat in the tempering process to leave the chisel a bit harder than standard. Paring and chopping are very different task. Leaving the steel in the blade a bit harder promotes a sharper edge better for paring than chopping.
(6) All sharp edges on the chisel blade where one’s hand may come in contact are broken/softened to make the user experience more pleasant and less wearing on the hand.
Below are pictures of the product created using this criteria. Woods are Desert ironwood, olive and figured resin infused maple.
Ron
New Additions to the Tools Available Page
Recent additions to the Tools Available Page as of January 28th, 2021.
To purchase visit the "Tools Available page"
Pair of Resin Infused Curly maple 18 degree Skew Chisels, 3/8" wide
Resin Infused Cherry Awl with removable blade feature and lye aged finish.
Most Recent Set of Dovetail Chisels
I recently completed this set of Dovetail chisels using Resin Infused Curly Maple for the handles. I also implemented a new ferrule design. The change is not obvious as it is concealed in the handle. The new ferrules feature an integrated threaded stud that actually threads into the handle and once thread locked it becomes integrated into the wooden handle.
This new feature allows all the components to become one thing and makes the final assembly a bit more predictable as well.
I had intended to list these chisels on the Tools Available page today but a former customer discovered that I had these in process and contacted me about purchasing them. Chisels are SOLD.
Ron
New Items Added to the Tool Available page on 9/2/20
To access that page follow this link. Tools Available
If you have any questions please contact me at ronbrese1@gmail.com
New Tools Available Page
All Awls are sold.
The awls featured in the last post sold quite quickly so I set about making another small batch of these tools in various woods. I also thought this might be a good time to create a page specifically for the tools that I have available for sale at any given time. Tools Available link.
Awl Issue Resolved
I guess if I really wanted I could fashion a jig to accomplish this task but as of late I've just made a new awl.
The obvious solution is to make an awl with a removable blade that is then easily chucked into a drill and spun against an abrasive to create a newly sharpened tip. This past week I've made a prototype of such an awl and have also made a small production run of removable blade awls.
It's Hot!!! (Chisels are Sold)
I've suspended outdoor projects for a while and have retreated into the shop to resume tool making.
I've recently completed another set of the diminutive Dove Tail chisels. This set features resin infused very curly maple handles. My friend and saw maker Ron Bontz is set up to do this infusing work and has a good bit of experience in the process. The maple turns much nicer after being infused and the figure is dazzling.
Sizes are 3/16, 1/4, 5/16, 3/8 and 1/2".
I've used Presco 0-1 tool steel for the blades on this set. It's a very high quality tool steel. It's the same tool steel I've used and enjoyed for plane irons.
Enjoy the rest of the summer, stay cool and safe,
Ron
Another Set of Desert Ironwood Chisels and a Popeye Awl (Chisels are Sold)
You may think this set of chisels looks quite similar to the chisels in the last post and I would have to agree but there is one significant difference. The steel used in the blades is Japanese Hitachi White Paper steel.
The Hitachi steel is proclaimed to be very pure steel and I have to say I could tell a difference as soon as I started roughing out the blades in the bandsaw. This stuff works lovely. Given the expense of obtaining this material I'm glad there were more benefits than just a difference in the hardened results.
Considering the price of the White Paper Steel these chisels are priced at $110 each with $5 per chisel discount for purchasing the entire set of 6. Total $630.
A Recently Completed Set of Chisels with Desert Ironwood Handles (This Set of Chisels is Sold)
I had intended to post this latest set of small Dovetail chisels earlier this week but a very close encounter with a tornado delayed things a bit. The line of storms that ripped thru the southeast Sunday night to early Monday morning caused a lot of havoc. We were awakened at 2:00 am Monday morning by our phones instructing us to "TAKE SHELTER NOW!!!"
We heard the distinctive roar of the tornado as we were standing in our bedroom closet and then it was over. We made the assumption that the tornado had passed over in the upper atmosphere. The next morning revealed a much different reality.
The tornado was a mile wide and was on the ground for 10 miles. The edge of the swath of destruction it left was literally 100 yards from our house. We were unbelievably lucky. Less than 2 miles from our property a house was moved from it's foundation intact and deposited in the middle of a state highway. Just a bit too close to OZ.
We were without power or cell service for 2 days. Obviously that wasn't much of an inconvenience compared to the devastating effect the storm had on the lives of the people in the path of destruction.
Now about the chisels. This is a 4 piece set and as I like to have all the handles in a set from the same piece of wood, I could only coax 4 handles from this piece of wood. This is especially true of Desert Ironwood. It can be so different from one blank to the next.
Dovetail Chisels, Something New and Interesting (Chisels are sold)
As a lot of you know I've been on somewhat of a hiatus from Tool making. It's been refreshing to pursue other types of work and it renews the spirit of creativity. I have made some tools along the way but mainly for my own needs.
I built what I would consider my dream shop for a someone else last year. It was a major construction undertaking that I wasn't sure I could accomplish. As in a lot of situations you find that you're capable of a lot more than you can imagine. For quite a while we could work at our leisure and then cover everything from the elements. We did this thru putting in the foundation, framing the floor and subsequently framed the walls and had them laying flat on the floor system. We could still cover everything with tarps so the weather wasn't much of a worry but then there's the day when you stand up walls and then you have all that time and material exposed to the elements and then it's a push to get dried in. It was a lot for two old guys to do but after a bit of trial and tribulation there came the day when it rained no more in the building. I can't even begin to express the relief.
But I digress. I then began pursuing some woodworking projects that had long languished on my list of things I wanted to make. Most of those things were joined with dovetails in one manner or other. I had a very adequate array of chisels for this work but soon discovered that I did not have what I would consider an optimum set of chisels for these task. I found myself picking up and putting down tools really more than should be required and finally came to the realization that with a proper set of chisels I could eliminate a lot of unnecessary movements. I began putting together a list of criteria that would describe this set of chisels.
I owned some shorter dovetail chisels that I really enjoyed, however they were 1/4" thick and given the way I typically layout my dovetails they would not fit between the ends of the tails to provide for incising the point where the side of the dovetail meets the baseline. In every case I had to put down one chisel to pick up another that was thin enough to fit.
Chopping base lines. When chopping to the baseline there should only be a minimal amount of material to be removed so an extravagant thickness is not required of a tool to accomplish this task. That sets one criteria. The second was length. It's nice to have a chisel short enough so that the base line where you're sticking the edge of the chisel and the top where you strike the chisel is in one line of sight. With longer chisels I would put the tip of the chisel in the base line and but when I changed my focus to where I would strike the handle the tip would move slightly. If you don't notice this then you end up with a wonky baseline. That sets another criteria to design for.
Personally I prefer good ole high carbon steel for my woodworking tools. At the last Forp Event where French/White oak was being worked profusely for days on end I noticed that everyone's chisels had serrated edges as the result of chopping in wood that had varying degrees of density. It didn't seem to matter if the chisels were A2 or PMV11 or High carbon steel. The end result was the same. The difference was in the time it takes to recover the edge. I realized years ago that a high speed steel edge that fractured took longer to recover than anytime one could possibly gain in edge longevity. I much prefer the sharper edge to be gained from using high carbon steel. I don't mind maintaining the edge as I work and when the edge does need to be restored with good technique it just doesn't take very long to be sharp and working again.
Evidently there are many others looking for a similar set of chisels because when I began posting pictures of the chisels I was making on my Instagram account I immediately started getting requests for these chisels. I took measures to get set up to produce these tools with a bit more efficiency and after a lot of trial and error and subsequent testing I was confident that I had a process by which to make very nice versions of these chisels.
The first 4 sets went out the door as soon as they were made and the set with Desert Ironwood handles pictured in this posting are the first I'll be offering for sale here on the blog.
As I mentioned this particular set has Desert Ironwood handles that all came from the same piece of timber. The ferrules are of course brass and the tool steel for the blades is New Old Stock Starret 0-1 tool steel. The overall length is 6". The sizes in this set are 3/16", 1/4", 5/16", 3/8" and 1/2". They are ground to have zero land on the edges but that edge is then broken so that it doesn't cut one's fingers as they are used. It's as minimal a land as can be had and not be dangerous to the user. The backs are polished and they come honed and working sharp.
The blade tips are taken into the heat treating process in a blunt state so that portion doesn't take such a beating in the hardening process and are subsequently ground back twice prior to final honing to make sure they are worked back into good steel.
The Web Page is No More
What I said about assuming the worse. I'm doing well, in fact I'm better than I've been for a while. In the last couple years I've shed 56 lbs. I'm more active than usual and feeling great.
I've been pursuing other interest, in fact I've been the General Contractor on a construction project since this past spring. As this project is winding down I'm back to restoring vintage machines and making planes again. I'm also doing more woodworking than I have for quite a while, in fact I'm about to embark on another work bench build. Not for myself. This is a commissioned piece for a client.
So there you have it, I hope you are all well and enjoying your woodworking,
Ron
Another "JR" plane, another Brese/Kennedy Creation
Just making this plane in the simplest functional form is quite a task. Coordinating both our efforts together adds an entire other element to this work but that keeps it's fresh and interesting and also makes it quite a challenge.
This is how it goes. I make all the parts. I mask all the areas of the interior of the plane that she is not to engrave and send them along to Catharine. She engraves the interior surfaces and all the movable/removable parts and sends them back to me. I then deburr, rub to a satin finish and oil the surfaces. Then I assemble the plane taking great care to preserve the engraved surfaces. There is no going back from here.
I then send the assembled plane body back to the Catharine to engrave the exterior of the plane body. She subsequently sends the plane body back to me. I work and oil the exterior surfaces, add the wooden bits, the iron and actually make the plane work.
Then it is shipped to our patron John Rexroad. Yes, these plane parts are quite traveled before this is done.
This is the third in this collection of tools. To date we have done a Winter Smoother, Winter Panel plane and now this Shooting plane.
When I post pics of these tools I always have people comment to me that this is way over the top for a "tool", and I realize this is not everyone's taste, however this format of tool making makes for a very rare collection of highly functional tools.
Ron
"The greatest challenge in life is discovering who you are. The second greatest is being happy with what you find"
Instagram is Easier than Blogging, and a Jewelry Box
If you're interested in what I've been up to as of late you may want to check out my Instagram page.
Here's a link:
https://www.instagram.com/breseplane/
And for those of you that don't wanna. Here's the jewelry box I mentioned in the title of this post.
The Saw Project is Complete
Workbenches, old American iron machine tools, my favorite hand tools. All these things are pleasing to my eye and inspired me to do work that is befitting of these tools.
There has been this one sore spot in my shop for quite a while that I've been meaning to do something about. The Grizzly table saw picture below is one that I purchased in 2004. Before I developed a taste for old American iron. There is really nothing particularly wrong with this saw that can't be resolved with new arbor bearings, belts and a considerable amount of tweaking. It has served me well but it just doesn't inspire me in the same way as my other tools. I removed the top a couple weeks ago to replace the arbor bearings. In the process it occurred to me this saw is basically an older model Delta Unisaw clone.
It All Started with Replacing the Arbor Bearings in my Table Saw
This is where things went wrong. As you know table saw dust collection is typically inadequate at best and while the top was off my saw I deemed this to be the time to design an improvement. 4 versions of a blade shroud later my saw dust collection is greatly improved. I'm into this project for way more days than I ever imagined and this spawned an entire re-arrangement of my shop. It was one of those, "while I'm at it I may as well", kind of thing.
The table saw has been moved forward and to the right approximately 2 feet. Doesn't sound like much of a task until you consider that the dust collection drop and the electrical feed also required moving. You can see evidence of the prior location in the picture below.
While the shop was in a total state of disarray I decided that now would also be the time to move my Powermatic 90 lathe to the other end of the shop. It's on a mobile base so easy right? Nope. This required me taking out the leg of my dust collection that went to the lathe, cap it off and then extend the main trunk of the system to the front end of the shop where the lathe now resides. Next I found myself crawling under my shop in order to pull a 220 volt circuit to the new lathe location while my wife was feeding the wire from inside the shop. Yes she is an extraordinary woman.
The lathe move was to facilitate moving my disc sander and oscillating spindle sander off a rolling tool chest into a fixed location on the back wall where the lathe used to reside. This required building cantilever brackets that attached to the back wall giving these tools a permanent home. I so hated having to roll that tool chest out every time I needed to use one of those tools. No more. Fortunately no electrical work was required for these machines. This sets me up to complete the finish work needed on the back wall of the shop. Trim and paint. You can see where the gray floor paint stops in the photo below. I'll be glad when the floor is all one color.
Last but not least Julie emptied out the cupboards of my Shaker workbench so we could change it's location. Even with the cupboard empty it was still quite heavy. That's part of why it's such a good workbench. We rocked it so that we could slide cardboard skids underneath. All this to move it approximately 2 feet.
Of course now the main room of the shop had the look of, "was anyone hurt when the bomb went off?"
It was time for a major aftermath clean up.
This was the final part of the re-arrangement and it all started with changing arbor bearings.
Just so you know, you can follow Brese Plane on Instagram. I'm enjoying the Instragram account. It allows me to post things going on in the shop in closer to real time and it's less involved than writing a blog post which can be hard to find the time to do.
Ron
“Whenever you find yourself on the side of the majority, it is time to pause and reflect.”
-Mark Twain
Summertime!
For a bit over a week 4 of our grandchildren and their moms have been visiting. It's been a busy time that has passed very quickly. Too quickly. Soon they will be returning to Brooklyn and London and the house will be quiet again.
We made bird houses with the kids. It was great fun and I highly suggest this project for kids. The ages range from 3 to 9 and it was fun for all.
Previously Owned Brese Planes....or is it a Kit Plane?
If you run across one of these ads and are considering making a purchase there are some things you need to know.
(1) All the planes sold as completed planes came with a document of provenance. If the seller doesn't offer to include the document then you need to ask more questions as to the origin of the plane. Why? See number (2) below.
(2) In the early years of plane making I also sold kits so that others could enjoy the plane making experience as well. Recently one of these planes was offered on Ebay. The title of the ad did not make reference to it being a plane completed from a kit. One line in the description did in fact reveal this fact. For this reason you could well be buying a plane made by a first time plane maker. Needless to say there will be considerable differences between a plane made by a person that has completed hundreds of planes and one made by a first time plane maker. Fortunately the eventual buyer of this plane asked all the right questions and was fully aware of what they were buying.
(3) Kit planes do not have the"Brese" logo stamped or engraved into the front of the lever cap. If the lever cap lacks this logo it's a kit plane. If the logo is present send me a picture and I'll verify that it is original.
Below is a picture of two 650-55 J planes I completed a couple years ago.
Recently another similar plane has been offered for sale. But not made by me. Look familiar? I just wanted to make it clear the plane pictured below was not made at Brese Plane or by anyone affiliated with Brese Plane.
I was reminded recently that imitation is a sincere form of flattery.
Ron
"Beware the sheep that wants to save you from the Wolf"
You Tube Entertainment
We don't have commercial television. Years ago when we first moved into our house (after 4 years of construction) the upstairs was not yet finished. One of the upstairs rooms was to be our den of sorts. Actually it's a bedroom that we've decided to make our den. It's multipurpose. We have a sofabed in that room so it easily doubles as a guest room when need be. But I digress.
We built our house ourselves and you tend to get worn out doing so. After moving in it would have been easy to get complacent and drag our feet on finishing the upstairs. We decided, as an incentive, that we would not move the satellite for our television to the new house until the upstairs was finished. During that period of time we read a lot, listened to the radio a great deal and were quite happy doing without television. So when the room was completed we had grown quite accustom to not having commercial television. We quite enjoyed not being exposed to the constant bombardment of ads making us believe we needed things that quite frankly we did not need. It's sort of like the philosophy of not spending money on cheap things in order to buy one thing of great quality.
So after purchasing a television for the new room we decided to create a subscription to Netflix. this allows us to decide what we want to watch and when. Now I know there are many devices to allow you skip thru ads, etc., but between Netflix and a couple other sources of video content we are quite satisfied with our viewing options.
Being a maker of sorts I am of course interested in other people that are also makers of one kind or another and You Tube is a great source of this type content.
The Hand Tool woodworking community is quite unique and a group of people I'm quite proud to be associated with. But to think that we are solely unique in this world would be untrue. There is also an entire community of home shop machinist. With the amount of metal working I do it only makes sense that I would be interested in the goings on of that community as well. This community came about due to the efforts of a guy named Lyle Peterson, known on You Tube as Tubalcain. He started posting how to videos of machining operations and quickly found that he had numerous subscribers which encouraged him to post more and more videos. Then came along other personalities like Adam Booth, known as Abom79, and Keith Rucker of Vintage Machinery.org. If interested click their names to obtain links to their You Tube channels. This is just the tip of the iceberg, so to speak. On these You Tube creators pages you will find links to many others.
And then there's the woodworking channels. This can be a quagmire of many many channels to sort thru to find the ones worth time for your particular interest. It seems every person with a table saw, router and random orbit sander thinks they have a wealth of knowledge to share with the world. I've noticed the more outlandish the personality of the host the less real skill they have to share. In other words they're trying to make up in personality what they lack in actual woodworking talent. There are the exceptions however.
Jay Bates for instance. Jay uses a mixture of machine tools and hand tools to complete his projects. That's a work method many can relate to. He is also a talented video editor and does interesting things with special effects. This makes his work quite interesting and entertaining. See the video below of Jay building a hickory side table.
Treebangham is another You Tube creator that I enjoy. Ken Bangham is a very skilled hand tool woodworker. Not only do I enjoy the actual projects he builds, I also enjoy and learn from his methods of hand tool work. I was inspired by his videos to make a Japanese tool box and subsequently I also made tool trays that help keep my bench top organized and these trays are stored in the Japanese tool box.
You'll notice that Ken is a bit more verbal in his videos than some, but that's okay because he does it well and uses it as a method to teach and entertain simultaneously.
Recently I've been watching Ishitani Furniture. Natsuki Ishitani is a young man who lives at the base of a volcano in Japan. Even though most Americans might think a Japanese craftsman using power tools and hand tools is a bit unusual, it's probably more common that we might imagine. Is Natsuki the most talented woodworker I've watched? Probably not, but I do like his non verbal style and his dog has loads of personality. His youthful enthusiasm and the way he attacks his work is fun to watch and the video is put together in a very interesting way. The music toward the end of his projects is very tastefully selected and seems to reflect the mood of the project. Bear in mind he's not afraid to knock stuff together with a hammer. Very forcefully I might add. I like his design atheistic and the deliberate way he carries out his work.
In most cases when the host starts his video very in your face I'm immediately turned off. Like I mentioned before, in most case those creators have very little to share in real skill and are trying to win your subscription with an alter ego persona. This can be very annoying.
If you have to continually tell me how cool something is........it probably isn't.
Good luck perusing You Tube for quality woodworking content,
Ron
"Woodworker is just another name for Procrastinator"
Michael Dunbar, WIA Berea Kentucky 2008









































































